排污泵因为作业环境相对恶劣复杂，若不注重日常养护，各类异常故障的发生概率相较其他泵类产品要高，发生锈蚀的排污泵往往开机困难，无法正常完成输运工作。

像这种情况只能通过拆泵后替换锈蚀严重的部件来恢复使用，而且发生锈蚀的部件如果十分严重，出现卡死情况，拆卸起来就会困难许多，可以通过加热的方式来降低拆卸难度，配合木锤敲击和一字螺丝刀进行撬，尽量避免硬拉，以防损坏泵体。根据实际锈蚀情况，还可考虑在锈蚀的间隙中滴入润滑油浸透片刻，可以进一步降低拆卸难度。

大发云从以往的排污泵使用经验来看，通常是使用完毕后不排除积水，或者长时间存放在潮湿中导致的锈蚀。不锈钢排污泵并非不会生锈，只是相对于一般的钢铁而言，所能适应的环境更为广泛，但若存放或者日常保养不当，依然是有可能会生锈的。

大发云在停用排污泵后及时排进泵内积液，如果一定时间内不会再使用，则尽量存放在清洁通风的环境中；

大发云长时间不用的排污泵不要直接放置于液下不管，应当及时收纳后储存，减少电机受潮的机会，同时也减少受到锈蚀的概率；

定期检查排污泵的运行参数和各个组件的完好性，可有效预防异常工况的出现。

Due to the relatively harsh and complex working environment of the sewage pump, if we do not pay attention to daily maintenance, the probability of various abnormal faults is higher than that of other pump products. The rusted sewage pump is often difficult to start and cannot complete the transportation work normally.

大发云In this case, it can only be restored to use by replacing the severely rusted parts after dismantling the pump. If the rusted parts are very serious and get stuck, it will be much more difficult to disassemble. The difficulty of disassembly can be reduced by heating. It can be pried with a wooden hammer and a slotted screwdriver to avoid hard pulling as far as possible to prevent damage to the pump body. According to the actual corrosion situation, it can also be considered to drip lubricating oil into the corrosion gap and soak it for a moment, which can further reduce the difficulty of disassembly.

大发云From the previous experience of using sewage pumps, it is usually caused by not removing ponding after use, or corrosion caused by storing in humidity for a long time. Stainless steel sewage pump is not free from rust, but it can adapt to a wider environment than ordinary steel, but it is still likely to rust if it is stored or maintained improperly.

After stopping the sewage pump, drain the accumulated liquid into the pump in time. If it will not be used for a certain period of time, store it in a clean and ventilated environment as far as possible;

Sewage pumps that have not been used for a long time should not be placed directly under the liquid. They should be stored after being stored in time to reduce the chance of the motor getting damp and the probability of corrosion at the same time;

大发云Regularly check the operating parameters of the sewage pump and the integrity of each component, which can effectively prevent the occurrence of abnormal working conditions.

高扬程污水泵